Product ID:SEMIGLOSS FAST AIR DRY ENAMEL 26307
MSDS Date:06/12/1991
FSC:8010
NIIN:01-042-1426
MSDS Number: BPKXX

RANDOLPH PRODUCTS CO

701 12TH STREET
CARLSTADT, NJ 07072-0830
US

Emergency Phone: 201-438-3700

Info Phone: 201-438-3700

Preparer: LG

Cage: 77672

RANDOLPH PRODUCTS CO

830 CARLSTADT, NJ 07072-0830 US

Telephone: 201-438-3700

Cage: 77672

SYNTHETIC RESIN SOLUTION (VAPOR PRESSURE 10.0 MM HG @ 20 C)

Fraction By Weight: 20%

ACGIH TLV: 100 PPM/150 PPM STEL

MEDIUM OIL ALKYD RESIN SOLUTION (VAPOR PRESSURE 3.1 MM HG @

Fraction By Weight: 10%

ACGIH TLV: 500 PPM

AROMATIC SOLVENT NAPHTHA (VAPOR PRESSURE 7.1 MM HG @ 20 C)

CAS: 64742-95-6

Fraction By Weight: 5%

ACGIH TLV: 50 PPM

ALIPHATIC MINERAL SPIRITS (VAPOR PRESSURE 10 MM HG @ 20 C)

CAS: 8052-41-3

RTECS: WJ8925000

Fraction By Weight: 10%

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM; 9293

XYLENE (VAPOR PRESSURE 10 MM HG @ 20 C) (SARA 313)

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 25%

ACGIH TLV: 100 PPM/150 PPM STEL

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Health Hazards Acute and Chronic:CHRONIC HEALTH EFFECTS ARE POSSIBLE
FROM LONG TERM EXPOSURE TO THIS MATERIAL, INCLUDING
DRYING/CRACKING/IRRITATION OF SKIN. REACTS WITH SKIN PROTEIN AND
MOISTURE AND CAN CAUSE RASH/SCALING/BLISTERING. HIGH
CONCENTRATIONS MAY CAUSE HEADACHES/DIZZINESS/ARE ANESTHITIC/OTHER
CENTRAL NERVOUS SYSTEM EFFECTS/DEATH.
Medical Cond Aggravated by Exposure:PRE-EXISTING SENSITIVITY TO
SOLVENTS CAN CAUSE A HEIGHTENED REACTION TO EXPOSURE TO THIS
PRODUCT. CONTACT LENS WEARERS SHOULD CONSULT PROVIDER BEFORE
HANDLING. CONSULT DR. IMMEDIATELY IF EYE CONTACT.

First Aid:INHALE: MOVE TO FRESH AIR, RESTORE BREATHING. CONSULT DR.
SKIN CONTACT: FLUSH W/WATER. EYE CONTACT: FLUSH IMMEDIATELY W/LARGE
AMOUNTS WATER. CONSULT DR. DO NOT INDUCE VOMITING. KEEP PERSON
WARM. CONSU LT DR. SMALL AMOUNTS LIQUID ASPIRATED INTO RESPIRATORY
SYSTEM DURING INGESTION/VOMITING MAY CAUSE CHEMICAL
PHEUMONIA/PULMONARY EDEMA. CONTAINS XYLENE, HAS SHOWN REPRODUCTIVE
EFFECTS IN MICE.

Flash Point Method:SCC
Flash Point:86.0F,30.0C
Lower Limits:0.9
Upper Limits:7.0
Extinguishing Media:ALCOHOL, DRY CHEMICAL, CARBON DIOXIDE, FOAM, WATER
FOG.
Fire Fighting Procedures:WATER STREAM WILL SPREAD FIRE. DO NOT USE
WATER HOSE STREAM, FULL BUNKER GEAR IN FIRE AREA (HELMET /FACE
SHIELD/BUNKER COAT/GLOVES/RUBBER BOOTS).
Unusual Fire/Explosion Hazard:CNTNRS CLSD. NO HEAT/SPARKS/OPEN FLAME.
CLSD CNTNRS EXPLODE EXPOSED-EXTREME HEAT. WATER COOL CLSD
CNTNRS-PREVENT PRESSURE BUILD-UP/POSSIBLE AUTOIGNITION/*

Spill Release Procedures:AVOID BREATH VAPOR. ENSURE VENT. NO
SPARKS/FLAMES/FIRE SOURCES. ELIM SOURCE IF W/O RISK BY CLOSING
VALVE/PLUGGING HOLE/ETC. APPLY ABSORBENT INERT MATERIAL
(SAND/DUST/VERMICULITE). CLEAN SPILL WITH BRI STLE
BROOMS/NON-SPARKING TOOLS/CLEAN DRY RAGS.

Handling and Storage Precautions:DRUMS SHOULD BE GROUNDED WHEN BEING
EMPTIED.
Other Precautions:PROVIDE RESPIRATORY PROTECTION AGAINST GENERATED
DURING BURNING. *EXPLOSION WHEN EXPOSED-EXTREME HEAT. REMOVE
NON-ESSENTIAL PERSONNEL. VAPOR IS HEAVIER THAN AIR AND CAN TRAVEL
CONSIDERABLE DISTANCES T O A SOURCE OF IGNITION AND FLASHBACK.

Respiratory Protection:NIOSH/OSHA APPROVED RESPIRATOR. APPROVED
CHEMICAL/MECHANICAL FILTERS RECOMMENDED WHEN VENT IS RESTRICTED.
CAUTION TAKEN AGAINST BREATHING VAPORS/CONTACT W/EYES/SKIN. PROTECT
AGAINST EXPOSURE TO VAPOR/ SPRAY MIST.
Ventilation:SUFFICIENT IN VOLUME/PATTERN-CONTAMINATION BELOW CURRENT
APPLIC OSHA PERMISS EXPOSURE LIMIT/ACGHI'S TLV LIMIT. **
Protective Gloves:GLOVES
Eye Protection:CHEM GOGGLES/SIDE SHIELDS/FACE SHIELDS
Other Protective Equipment:PROTECTIVE CREAMS FOR SKIN CONTACT.
REMOVE/WASH CONTAM CLOTHING BEFORE REUSE. PROTECTIVE CLOTHING WHEN
SPILL CLEAN-UP.
Work Hygienic Practices:USE NORMAL HYGENE PRACTICES DURING AND AFTER
HANDLING THIS MATERIAL.
Supplemental Safety and Health

Boiling Pt:B.P. Text:279FTO410F
Vapor Density:>AIR
Spec Gravity:10.7LBS/GAL(US)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:UNDER 25%
Appearance and Odor:THIN GREY LIQUID
Percent Volatiles by Volume:53.5

Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:AVOID STRONG OXIDIZERS, ACIDS, AND ALKALI.
Hazardous Decomposition Products:THERMAL DECOMPOSITION RELEASES CARBON
MONOXIDE AND/OR CARBON DIOXIDE.

Waste Disposal Methods:SOAK LIQUIDS W/SAWDUST/RAGS/REMOVE. FLUSH
W/WATER. NO SKIN CONTACT. DISPOSAL IN ACCORDANCE W/LOCAL/STATE/FED
REGS. NO INCINERATE/CUT/WELD EMPTY CONTAINERS. WHEN DISCARDED MAT'L
IS HAZARDOUS WASTE. TRA NSFER LIQUID TO CONTAINERS FOR
RECOVERY/DISPOSAL.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.